Manitowoc QF0800 Especificaciones Pagina 281
- Pagina / 308
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
Part Number 80-1230-9 6/08 281
QF2200/RFC2085
REMOTE AIR-COOLED
Characteristics will vary depending on operating
conditions.
24-HOUR ICE PRODUCTION
Air Temperature
Entering
Condenser
°F/°C
Water Temperature
°F/°C
50/10 70/21 90/32
70 21 2150 1980 1840
80 27 2050 1870 1750
90 32 1870 1750 1635
100 38 1650 1530 1410
110 43 1400 1300 1250
OPERATING PRESSURES (PSIG)
Air Temperature
Entering
Condenser
°F/°C
Freeze Cycle
Discharge
Pressure
Suction
Pressure
-20 to 50F
-29 to 10C
220-245
175-185*
14-18
70 21
220-250
210-225*
17-21
80 27 245-270 18-22
90 32 250-275 19-23
100 38 315-330 23-26
110 43 355 -75 25-28
*Headmaster Part Number 82-5116-3 Only
- Technician’s 1
- Handbook 1
- Safety Notices 3
- Procedural Notices 3
- ! Warning 4
- Table of Contents 5
- 6 Part Number 80-1230-9 6/08 6
- Part Number 80-1230-9 6/08 7 7
- 8 Part Number 80-1230-9 6/08 8
- General Information 9
- S N 0658 A 10
- Important 11
- 12 Part Number 80-1230-9 6/08 12
- Part Number 80-1230-9 6/08 13 13
- 14 Part Number 80-1230-9 6/08 14
- Ice Machine 14
- Twelve months from the 14
- Part Number 80-1230-9 6/08 15 15
- 16 Part Number 80-1230-9 6/08 16
- Part Number 80-1230-9 6/08 17 17
- 18 Part Number 80-1230-9 6/08 18
- Installation 19
- SN12/SN20 20
- BTU/Hour 21
- Part Number 80-1230-9 6/08 23 23
- 28 Part Number 80-1230-9 6/08 28
- Part Number 80-1230-9 6/08 29 29
- LINE SET REQUIREMENTS 30
- Traditional Remote Units Only 30
- 32 Part Number 80-1230-9 6/08 32
- Component Identification 33
- Remote & QuietQube Models 34
- QF800/QC700 35
- 36 Part Number 80-1230-9 6/08 36
- Maintenance 37
- 38 Part Number 80-1230-9 6/08 38
- Part Number 80-1230-9 6/08 39 39
- 40 Part Number 80-1230-9 6/08 40
- Part Number 80-1230-9 6/08 41 41
- 42 Part Number 80-1230-9 6/08 42
- Part Number 80-1230-9 6/08 43 43
- Part Number 80-1230-9 6/08 45 45
- 46 Part Number 80-1230-9 6/08 46
- Part Number 80-1230-9 6/08 49 49
- 52 Part Number 80-1230-9 6/08 52
- Part Number 80-1230-9 6/08 53 53
- 54 Part Number 80-1230-9 6/08 54
- 5. Lift out ice damper 55
- 56 Part Number 80-1230-9 6/08 56
- Part Number 80-1230-9 6/08 57 57
- 58 Part Number 80-1230-9 6/08 58
- 60 Part Number 80-1230-9 6/08 60
- Part Number 80-1230-9 6/08 61 61
- 6. Remove front cover 62
- A. Lift up on front cover 62
- 7. Remove side panels 62
- 8. Remove ice chute cover 63
- B. Lift to remove cover 63
- 9. Lift out ice damper 64
- Part Number 80-1230-9 6/08 65 65
- 66 Part Number 80-1230-9 6/08 66
- Part Number 80-1230-9 6/08 67 67
- 68 Part Number 80-1230-9 6/08 68
- Part Number 80-1230-9 6/08 69 69
- 70 Part Number 80-1230-9 6/08 70
- Part Number 80-1230-9 6/08 71 71
- 18. Remove ice deflector 72
- Part Number 80-1230-9 6/08 73 73
- 74 Part Number 80-1230-9 6/08 74
- Part Number 80-1230-9 6/08 75 75
- 76 Part Number 80-1230-9 6/08 76
- 78 Part Number 80-1230-9 6/08 78
- Model Amount of Cleaner 78
- QF0400 2 oz. (60 ml) 78
- Part Number 80-1230-9 6/08 79 79
- 80 Part Number 80-1230-9 6/08 80
- Part Number 80-1230-9 6/08 81 81
- Part Number 80-1230-9 6/08 83 83
- 86 Part Number 80-1230-9 6/08 86
- Part Number 80-1230-9 6/08 87 87
- 88 Part Number 80-1230-9 6/08 88
- Part Number 80-1230-9 6/08 89 89
- 90 Part Number 80-1230-9 6/08 90
- Part Number 80-1230-9 6/08 91 91
- 94 Part Number 80-1230-9 6/08 94
- Part Number 80-1230-9 6/08 95 95
- 98 Part Number 80-1230-9 6/08 98
- Part Number 80-1230-9 6/08 99 99
- WATER LEVEL 102
- FLOAT VALVE 105
- Water Reservoir Removal 106
- Dump Valve Disassembly 110
- Door Removal 111
- Operation 115
- ENERGIZED PARTS 118
- Energized Parts 125
- Energized Parts (Continued) 126
- Troubleshooting 133
- Ice Machine Will Not Run 134
- Replace HES #2 135
- IMPORTANT 136
- Machine Will Start 136
- OPERATIONAL PROBLEM CHECKLIST 141
- (disch temp, water level or 148
- No Water Checklist 151
- Gear Motor Speed Checklist 153
- Temperature Sensor Checklist 156
- QF0400/QC0700/QF0800 156
- Component Check Procedures 167
- Step 3 Check for Continuity 168
- Reading Result 168
- Open Replace the switch 168
- Continuity Cause 172
- No Replace bin level probe 172
- Yes Go to step 3 172
- DISCONNECT BIN LEVEL PROBE 174
- FROM CONTROL BOARD 174
- DISCONNECT 178
- WATER LEVEL PROBE 178
- PROBE LIGHT 178
- Depressed Closed 186
- Released Open 186
- Speed Sensor 189
- HPR SOLENOID 195
- HPR VALVE 196
- Cooling Mode 211
- Cut-Out at Setpoint 211
- Contamination Cleanup Chart 223
- USING PINCH-OFF TOOL 228
- Evaporator Re-Build Kits 235
- CONTENTS OF THE RE-BUILD KIT: 236
- SPLINE HUB AND KEY STOCK 237
- EVAPORATOR REASSEMBLY 239
- Component Specifications 247
- Refrigerant Pressure Charts 251
- SN012A/SN020A 252
- SELF-CONTAINED AIR-COOLED 252
- QF0400A BRONZE EVAPORATOR 254
- SELF-CONTAINED WATER-COOLED 256
- Condenser Water Consumption 256
- QUIETQUBE REMOTE AIR-COOLED 261
- REMOTE AIR-COOLED 264
- SF900C/RFC985 271
- 24-HOUR ICE PRODUCTION 272
- SN950C/RFC985 274
- SF1200C/RFC1285 277
- SN1250C/RFC1285 280
- QF2200/RFC2085 281
- QF2300/RFC2385 282
- Diagrams 283
- 115/60/1 – 230/50/1 285
- QF0400 115/60/1 – 230/50/1 286
- 115/60/1 – 230/50/1 289
- QF2200 115/60/1 – 230/50/1 290
- RFC2385 CONDENSING UNIT 294
- 230/60/1 – 230/50/1 294
- 208 - 230/60/3 295
- SN012/SN020 299
- SF0400/SN0450/SF0600/SN0650 300
- SF0900/SN0950/SF1200/SN1250 301
- Air Cooled 301
- SF0600/SN0650 302
- Remote Air Cooled 302
- Air & Water Cooled 303
Relacionado con productos y manuales para Máquinas productoras de hielo Manitowoc QF0800
(272 paginas)© 2020, manymanuals.es. Todos los derechos reservados | 0.092 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales