Manitowoc S model Especificaciones Pagina 279
- Pagina / 292
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
Part Number 80-1230-9 10/10 279
Control Board Lights
#1 Nugget - Red, indicate the control is configured for
nugget ice machines.
#2 Flaker - Red, indicates the control is configured for
flaked ice machines.
#3 HES #1 - Green, works in conjunction with the Hall
Effect Switch #1. When the ice damper is closed the
light is on.
#4 HES #2 - Green, works in conjunction with the Hall
Effect Switch #2. When the ice damper is closed the
light is on.
#5 Clean - Yellow, indicates the unit is in a clean
sequence.
#6 Maint. - Red, indicates that maintenance is
required. Only used when configured for nugget.
#7 Water - Energizes when the water level in the
reservoir closes (raises) the float switch. De-energizes
when the float switch opens.
Racing Lights - All lights racing indicates a 5-minute
delay period is timing out.
- Manitowoc 1
- Safety Notices 3
- Procedural Notices 3
- ! Warning 4
- Table of Contents 5
- 6 Part Number 80-1230-9 10/10 6
- Part Number 80-1230-9 10/10 7 7
- 8 Part Number 80-1230-9 10/10 8
- Part Number 80-1230-9 10/10 9 9
- General Information 13
- Q F 0807 W 14
- Important 15
- Commercial Warranty 16
- Residential Warranty 18
- Installation 23
- SN12/SN20 24
- Ice Machine Heat of Rejection 25
- Remote condensing units 26
- Electrical Service 27
- Supply and Drains 31
- LINE SET REQUIREMENTS 34
- Traditional Remote Units Only 34
- Component Identification 37
- Maintenance 43
- Amount of Cleaner Part 46
- Number 000000084 46
- QF0400 2 oz. (60 ml) 46
- ADD SOLUTION HERE 51
- Heavily Scaled Procedure 53
- Amount of Cleaner 54
- Part Number 000000084 54
- And Sanitizing 65
- TRACK SLOT 69
- SLIDE DOOR 69
- PRESS DOWN TO 69
- RELEASE DOOR 69
- FLOAT VALVE 74
- RESERVOIR 75
- EVAPORATOR 75
- ASSEMBLY 75
- LOOSEN SCREWS 78
- 11. Lift out ice damper 80
- REMOVE SCREW 82
- 6. Remove front cover 85
- A. Lift up on front cover 85
- 7. Remove side panels 85
- 8. Remove ice chute cover 86
- B. Lift to remove cover 86
- 9. Lift out ice damper 87
- ICE CHUTE 90
- ICE CHUTE DRAIN 90
- REMOVE THUMBSCREWS 93
- THUMBSCREW 94
- 18. Remove ice deflector 95
- Dump Valve Disassembly 99
- Operation 105
- Energized Parts 110
- Energized Parts (Continued) 111
- ENERGIZED PARTS 119
- Troubleshooting 121
- No Water Checklist 124
- Gear Motor Speed Checklist 126
- QF0400/QC0700/QF0800 129
- Temperature Sensor Checklist 129
- Reset Procedure 134
- Ice Machine Will Not Run 141
- Replace HES #2 142
- IMPORTANT 143
- Machine Will Start 143
- Refrigeration Diagnostics 146
- WATER SYSTEM CHECKLIST 147
- Component Check Procedures 153
- Continuity Cause 158
- No Replace bin level probe 158
- Yes Go to step 3 158
- DISCONNECT BIN LEVEL PROBE 160
- FROM CONTROL BOARD 160
- DISCONNECT 164
- WATER LEVEL PROBE 164
- WATER LEVEL 164
- PROBE LIGHT 164
- Speed Sensor 166
- QF2200 Only 169
- QF2300 Only 170
- Cooling Mode 172
- Cut-Out at Setpoint 172
- S Model Nugget/Flake 176
- Step 3 Check for Continuity 178
- Reading Result 178
- Open Replace the switch 178
- SN012/SN020 Only 182
- Depressed Closed 183
- Released Open 183
- All Models 185
- Headmaster Control Valve 193
- System Contamination Clean-Up 202
- Contamination Cleanup Chart 203
- USING PINCH-OFF TOOL 208
- Gear Box Removal 210
- Evaporator Re-Build Kits 216
- Contents of the Re-Build Kit: 217
- SPLINE HUB AND KEY STOCK 218
- EVAPORATOR REMOVAL 222
- Component Specifications 229
- Refrigerant Pressure Charts 233
- SN012A/SN020A 234
- SELF-CONTAINED AIR-COOLED 234
- QF0400A BRONZE EVAPORATOR 236
- SELF-CONTAINED WATER-COOLED 238
- Condenser Water Consumption 238
- QUIETQUBE REMOTE AIR-COOLED 243
- REMOTE AIR-COOLED 246
- SF900C/RFC985 253
- 24-HOUR ICE PRODUCTION 254
- SN950C/RFC985 256
- SF1200C/RFC1285 259
- SN1250C/RFC1285 262
- QF2200/RFC2085 263
- QF2300/RFC2385 264
- Diagrams 265
- QF0400 115/60/1 – 230/50/1 266
- 115/60/1 – 230/50/1 269
- QF2200 115/60/1 – 230/50/1 270
- RFC2385 CONDENSING UNIT 274
- 230/60/1 – 230/50/1 274
- 208 - 230/60/3 275
- 115/60/1 – 230/50/1 277
- Electronic Control Boards 278
- Air & Water Cooled 281
- Remote Air Cooled 282
- SN012/SN020 284
- SF0400/SN0450/SF0600/SN0650 285
- SF0900/SN0950/SF1200/SN1250 286
- Air Cooled 286
- SF0600/SN0650 287
© 2020, manymanuals.es. Todos los derechos reservados | 0.082 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales