Manitowoc S model Especificaciones Pagina 137
- Pagina / 292
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
Part Number 80-1230-9 10/10 137
QF0400/QC0700/QF0800/QF2200/QF2300 OPERATIONAL PROBLEM CHECKLIST
Problem Possible Cause To Correct
Ice machine does not operate. No electrical power to the ice machine.
Replace the fuse/reset the breaker/turn on the
main switch/plug power cord into receptacle.
Control board fuse open.
ICE/OFF/CLEAN toggle switch set improperly. Move the toggle switch to the ICE position.
8-minute lockout has not expired.
Bin Level light will flash to indicate 8-minute
lockout has not expired. Refer to sequence of
operation.
Bin level sensor is disconnected or is
contacting the ice.
Connect bin level sensor or remove ice
contacting probe.
High Pressure Control is open.
Clean condenser, check fan motor, check high
pressure control operation.
Gear motor runs but compressor will not start.
Remote Condenser Only
Water reservoir is empty.
(Water must contact the water level probes to
start the compressor.)
Open water service valve or clean float valve
screen.
Water level probes out of position. Correct water level probe position.
Water float valve will not energize electrically. Replace coil.
No electrical power to condensing unit.
Replace the fuse/reset the breaker/turn on the
main switch.
- Manitowoc 1
- Safety Notices 3
- Procedural Notices 3
- ! Warning 4
- Table of Contents 5
- 6 Part Number 80-1230-9 10/10 6
- Part Number 80-1230-9 10/10 7 7
- 8 Part Number 80-1230-9 10/10 8
- Part Number 80-1230-9 10/10 9 9
- General Information 13
- Q F 0807 W 14
- Important 15
- Commercial Warranty 16
- Residential Warranty 18
- Installation 23
- SN12/SN20 24
- Ice Machine Heat of Rejection 25
- Remote condensing units 26
- Electrical Service 27
- Supply and Drains 31
- LINE SET REQUIREMENTS 34
- Traditional Remote Units Only 34
- Component Identification 37
- Maintenance 43
- Amount of Cleaner Part 46
- Number 000000084 46
- QF0400 2 oz. (60 ml) 46
- ADD SOLUTION HERE 51
- Heavily Scaled Procedure 53
- Amount of Cleaner 54
- Part Number 000000084 54
- And Sanitizing 65
- TRACK SLOT 69
- SLIDE DOOR 69
- PRESS DOWN TO 69
- RELEASE DOOR 69
- FLOAT VALVE 74
- RESERVOIR 75
- EVAPORATOR 75
- ASSEMBLY 75
- LOOSEN SCREWS 78
- 11. Lift out ice damper 80
- REMOVE SCREW 82
- 6. Remove front cover 85
- A. Lift up on front cover 85
- 7. Remove side panels 85
- 8. Remove ice chute cover 86
- B. Lift to remove cover 86
- 9. Lift out ice damper 87
- ICE CHUTE 90
- ICE CHUTE DRAIN 90
- REMOVE THUMBSCREWS 93
- THUMBSCREW 94
- 18. Remove ice deflector 95
- Dump Valve Disassembly 99
- Operation 105
- Energized Parts 110
- Energized Parts (Continued) 111
- ENERGIZED PARTS 119
- Troubleshooting 121
- No Water Checklist 124
- Gear Motor Speed Checklist 126
- QF0400/QC0700/QF0800 129
- Temperature Sensor Checklist 129
- Reset Procedure 134
- Ice Machine Will Not Run 141
- Replace HES #2 142
- IMPORTANT 143
- Machine Will Start 143
- Refrigeration Diagnostics 146
- WATER SYSTEM CHECKLIST 147
- Component Check Procedures 153
- Continuity Cause 158
- No Replace bin level probe 158
- Yes Go to step 3 158
- DISCONNECT BIN LEVEL PROBE 160
- FROM CONTROL BOARD 160
- DISCONNECT 164
- WATER LEVEL PROBE 164
- WATER LEVEL 164
- PROBE LIGHT 164
- Speed Sensor 166
- QF2200 Only 169
- QF2300 Only 170
- Cooling Mode 172
- Cut-Out at Setpoint 172
- S Model Nugget/Flake 176
- Step 3 Check for Continuity 178
- Reading Result 178
- Open Replace the switch 178
- SN012/SN020 Only 182
- Depressed Closed 183
- Released Open 183
- All Models 185
- Headmaster Control Valve 193
- System Contamination Clean-Up 202
- Contamination Cleanup Chart 203
- USING PINCH-OFF TOOL 208
- Gear Box Removal 210
- Evaporator Re-Build Kits 216
- Contents of the Re-Build Kit: 217
- SPLINE HUB AND KEY STOCK 218
- EVAPORATOR REMOVAL 222
- Component Specifications 229
- Refrigerant Pressure Charts 233
- SN012A/SN020A 234
- SELF-CONTAINED AIR-COOLED 234
- QF0400A BRONZE EVAPORATOR 236
- SELF-CONTAINED WATER-COOLED 238
- Condenser Water Consumption 238
- QUIETQUBE REMOTE AIR-COOLED 243
- REMOTE AIR-COOLED 246
- SF900C/RFC985 253
- 24-HOUR ICE PRODUCTION 254
- SN950C/RFC985 256
- SF1200C/RFC1285 259
- SN1250C/RFC1285 262
- QF2200/RFC2085 263
- QF2300/RFC2385 264
- Diagrams 265
- QF0400 115/60/1 – 230/50/1 266
- 115/60/1 – 230/50/1 269
- QF2200 115/60/1 – 230/50/1 270
- RFC2385 CONDENSING UNIT 274
- 230/60/1 – 230/50/1 274
- 208 - 230/60/3 275
- 115/60/1 – 230/50/1 277
- Electronic Control Boards 278
- Air & Water Cooled 281
- Remote Air Cooled 282
- SN012/SN020 284
- SF0400/SN0450/SF0600/SN0650 285
- SF0900/SN0950/SF1200/SN1250 286
- Air Cooled 286
- SF0600/SN0650 287
© 2020, manymanuals.es. Todos los derechos reservados | 0.042 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales