Manitowoc SR1801W Especificaciones Pagina 151
- Pagina / 300
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
Part Number 80-1479-3 7/10 151
HARVEST ASSIST AIR PUMP
FUNCTION
The air pump breaks the vacuum between the sheet of
ice and the evaporator which results in shorter harvest
cycles.
SPECIFICATIONS
115 Volt or 230 Volt - matches the ice machine
voltage.
CHECK PROCEDURE
1. Verify when the air pump should be running in the
sequence of operation.
2. If the compressor is not running when it should be
check voltage at the control board.
3. If there is no voltage present at the control board,
replace the control board.
4. If there is voltage present at the control board
check for voltage at the air pump connector.
5. If there is no voltage present at the air pump
connector replace wire.
6. If there is voltage at the air pump connector, use a
volt ohm meter to verify there is no continuity
through the motor windings then replace motor.
- Manitowoc 1
- Safety Notices 3
- Procedural Notices 3
- Table of Contents 5
- 6 Part Number 80-1479-3 7/10 6
- Part Number 80-1479-3 7/10 7 7
- 8 Part Number 80-1479-3 7/10 8
- General Information 9
- ! Warning 10
- Energy Efficient Ice Machine 12
- Serial Breaks 12
- 14 Part Number 80-1479-3 7/10 14
- Part Number 80-1479-3 7/10 15 15
- 16 Part Number 80-1479-3 7/10 16
- Ice Machine 16
- Twelve months from the 16
- Part Number 80-1479-3 7/10 17 17
- 18 Part Number 80-1479-3 7/10 18
- Part Number 80-1479-3 7/10 19 19
- 20 Part Number 80-1479-3 7/10 20
- Installation 21
- 22 Part Number 80-1479-3 7/10 22
- Ice Machine Heat of Rejection 23
- Part Number 80-1479-3 7/10 25 25
- 26 Part Number 80-1479-3 7/10 26
- Part Number 80-1479-3 7/10 27 27
- Component Identification 29
- 30 Part Number 80-1479-3 7/10 30
- Maintenance 31
- 32 Part Number 80-1479-3 7/10 32
- 34 Part Number 80-1479-3 7/10 34
- Part Number 80-1479-3 7/10 35 35
- 36 Part Number 80-1479-3 7/10 36
- Continued on next page … 37
- 38 Part Number 80-1479-3 7/10 38
- Ice Machines 40
- 42 Part Number 80-1479-3 7/10 42
- Part Number 80-1479-3 7/10 43 43
- 44 Part Number 80-1479-3 7/10 44
- Part Number 80-1479-3 7/10 45 45
- 46 Part Number 80-1479-3 7/10 46
- Part Number 80-1479-3 7/10 47 47
- 48 Part Number 80-1479-3 7/10 48
- Part Number 80-1479-3 7/10 51 51
- Solution 51
- Water Mixed With 51
- 52 Part Number 80-1479-3 7/10 52
- Part Number 80-1479-3 7/10 53 53
- Part Number 80-1479-3 7/10 55 55
- Dump Valve Disassembly 55
- 56 Part Number 80-1479-3 7/10 56
- Part Number 80-1479-3 7/10 57 57
- 58 Part Number 80-1479-3 7/10 58
- Sequence of Operation 59
- 60 Part Number 80-1479-3 7/10 60
- Part Number 80-1479-3 7/10 61 61
- 62 Part Number 80-1479-3 7/10 62
- Part Number 80-1479-3 7/10 63 63
- Safety Timers 64
- Safety Limits 65
- 66 Part Number 80-1479-3 7/10 66
- Part Number 80-1479-3 7/10 67 67
- Self Contained Water-Cooled 70
- 72 Part Number 80-1479-3 7/10 72
- Part Number 80-1479-3 7/10 73 73
- 74 Part Number 80-1479-3 7/10 74
- Part Number 80-1479-3 7/10 75 75
- 76 Part Number 80-1479-3 7/10 76
- Remote Air-Cooled 77
- Part Number 80-1479-3 7/10 79 79
- 80 Part Number 80-1479-3 7/10 80
- Troubleshooting 81
- 82 Part Number 80-1479-3 7/10 82
- Part Number 80-1479-3 7/10 83 83
- 84 Part Number 80-1479-3 7/10 84
- Part Number 80-1479-3 7/10 85 85
- 86 Part Number 80-1479-3 7/10 86
- Part Number 80-1479-3 7/10 87 87
- Control Board Testing 88
- Troubleshooting By Symptom 89
- 90 Part Number 80-1479-3 7/10 90
- Part Number 80-1479-3 7/10 91 91
- 92 Part Number 80-1479-3 7/10 92
- Part Number 80-1479-3 7/10 93 93
- 94 Part Number 80-1479-3 7/10 94
- Part Number 80-1479-3 7/10 95 95
- S MODELS DUAL EXPANSION VALVE 100
- Important 110
- Harvest Problems 126
- Analysis Chart 129
- Refer to Symptom 129
- #2 - Freeze Cycle 129
- Component Check Procedures 135
- ICE THICKNESS ADJUSTMENT 147
- 8 to 22 ohms 157
- S1200/S1400/S1600/S1800 157
- S600/S850/S1000 157
- Refrigeration Components 158
- HPR SOLENOID 161
- HPR VALVE 161
- Specifications 167
- Cut-Out Cut-In 167
- 12 psig ±3 35 psig ±3 167
- RECOVERY/EVACUATION 170
- CONNECTIONS 170
- EXPANSION 177
- System Contamination Clean-Up 178
- Contamination Cleanup Chart 179
- USING PINCH-OFF TOOL 184
- Refrigerant Pressure Charts 191
- S300 SERIES 192
- S320 SERIES 196
- S320 Series 197
- S420 SERIES 198
- S450 SERIES 202
- S500 SERIES 206
- SD0502A 207
- SY0505W 211
- S600 SERIES 215
- S850 SERIES 218
- SD0892N 225
- SY0894N 226
- S1000 SERIES 227
- S1200 SERIES 236
- SD1202A 237
- S1400 SERIES 242
- SD1402A 243
- SY1404A 244
- SD1403W 246
- SY1405W 249
- SD1492N 251
- SY1494N 252
- S1600 SERIES 253
- S1800 SERIES 256
- S3300 SERIES 265
- Diagrams 267
- & ENERGYSTAR MACHINES 268
- Self Contained - 1 Phase 268
- S300/S420/S450/ 269
- S600/S850/S1000/S1200 270
- Self Contained- 1 Phase 270
- S850/S1000/S1200 271
- Self Contained - 3 Phase 271
- S500 Danfoss Compressor 272
- Remote - 1 Phase 272
- S600/S850/S1000/S1200 273
- Remote - 3 Phase 274
- S1400/S1600/S1800 275
- Self-Contained - 1 Phase 275
- Self-Contained - 3 Phase 276
- ENERGYSTAR MACHINES 279
- S300/S420/S450/S500 279
- S850/S1000/S1200 281
- S1400/S1800 282
- Water-Cooled - 3 phase 284
- FAN MOTOR 285
- RUN CAPACITOR 285
- Quad Evaporator Ice Machines 292
- S1400/S1600/S1800 293
- S500/S600/S850/S1000 295
Relacionado con productos y manuales para Máquinas productoras de hielo Manitowoc SR1801W
(236 paginas)
(38 paginas)
(44 paginas)© 2020, manymanuals.es. Todos los derechos reservados | 0.143 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales