Manitowoc MULTIPLEX 11M Especificaciones Pagina 93
- Pagina / 139
- Tabla de contenidos
- SOLUCIÓN DE PROBLEMAS
- MARCADORES
Valorado. / 5. Basado en revisión del cliente
00218012 Revision B (KAK) 7 August, 2000
16
Multiplex Company, Inc.
Fountain Troubleshooting Guide
Troubleshooting Guide
WARNING: Inspection, testing, and repair of elec-
trical equipment should be performed only by
qualified service personnel. The unit should be
unplugged when servicing, except when electri-
cal tests are required.
DANGER: Use extreme care during electrical cir-
cuit tests. Live circuits may be exposed.
Section 4: Compressed Air System
Until repairs can be made on Compressed Air System, place Air/CO2 Change-over Valve in the CO2 Oper-
ating position.
Qualifier Probable Cause Corrective Action
Air Compressor will not
cycle on and Air Pres-
sure Gauge registers
0psi.
Air Compressor cycles
on and off and Air
Pressure Gauge readings
range between 70 psi
(4.9 kg/cm
2
) to 90 psi
(6.3 kg/cm
2
).
No power to Air Compres-
sor.
Pressure Switch defective.
Motor defective.
Pump frozen.
Air/CO
2 Change-over Valve
placed in incorrect posi-
tion.
Malfunction of Syrup Sys-
tem.
Malfunction of Refrigera-
tion System.
Verify Toggle Switch to Air Compressor is in the
on position and main power supply is on.
Remove Pressure Switch Cover and use a volt-
meter across Switch to determine whether
open or closed. If in open position, re-
place switch.
Verify voltage across Motor with a voltmeter, if
Motor/Pump assembly will not operate, it is de-
fective and should be replaced.
Same as above for Motor defective.
Place Air/CO
2 Change-over Valve to the Air or
CO
2 operating position.
Note: If lever is positioned between Air and
CO
2 the gas supply is shut off to syrup sys-
tem.
Refer to Troubleshooting Section 8: Syrup Sys-
tem, under No syrup.
Refer to Troubleshooting Section 7: Refrigera-
tion System, under No carbonated water at
dispensing valves (freeze up).
No syrup
- Fountain 1
- Technical 1
- Handbook 1
- Complete 2
- Overview 2
- Carbonated Water 4
- Water Filter System 6
- Carbonation System 7
- Carbonator Pump on 8
- Multiplex Company, Inc 10
- Complete System Overview 10
- Circulating Pump 12
- Dual Carbonated Water Supply 13
- Dispensing System 15
- Maintenance Schedule 16
- Component 20
- Workbook 20
- Table of Contents (continued) 22
- Water Regulator 24
- Water Filter 25
- Accumulator Tank Pressures 26
- Primary Regulator 27
- Component Parts Workbook 28
- Carbonator Pump and Motor 29
- Carbonator Pumps 30
- Carbonator Pumps (continued) 31
- Water Bath Feeder 34
- Carbonator Tank 35
- Electrode 36
- Electrodes 37
- Liquid Level Control 38
- Cooling Coils 39
- Circulating Pump and Motor 40
- Function of conduit 42
- Failure of conduit 42
- Refrigeration Compressor 43
- RefrigerationUnits 47
- Condenser 49
- Refrigeration Lines 50
- Connecting the pre-charged 51
- Aeroquip Connection 52
- Expansion Valve or Cap Tube 53
- Evaporator Coil 54
- Water Bath 55
- Agitator Motor 56
- Ice Bank Control 57
- Reference Chart 59
- Reference Chart (continued) 60
- Dispensing Valves 62
- Flow Controls 63
- Keyboards and Timers 64
- Multiplex Programmable 65
- Portion Control Timers 65
- Whats New at 65
- Multiplex 65
- Special feature 67
- Test Procedures 68
- Dual Transformers 69
- Service Bulletin 70
- Adjusting portion control for 74
- Cancel/pour 74
- Installation 74
- Troubleshooting 76
- Foreword 79
- Problem Cross Reference Guide 80
- Troubleshooting Guide 100
- Illustrated 111
- Fittings and 111
- Hardware 111
- Abbreviations 112
- Table of Contents 112
- Ordering Parts 113
- Adaptors 114
- Barbed Connections 115
- Calibrating and Cleaning 118
- Cable Ties 118
- Check Valves 119
- Check Valves (continued) 120
- Syrup Filter 122
- Disconnects 122
- Flare Connections 123
- Pipe Connections 124
- Compression Fittings 125
- Pump Accessories 126
- Pressure Reliefs 126
- Regulators 127
- Strainers 127
- Insulation 127
- Tools (continued) 129
- Valves (continued) 132
- John Guest Fittings 133
- For stainless steel 137
- 00218009 Revision D July 2002 139
Relacionado con productos y manuales para No Manitowoc MULTIPLEX 11M
No Manitowoc KR-3 Manual de servicio
(57 paginas)
(57 paginas)
No Manitowoc MULTIPLEX 11M Especificaciones
(236 paginas)
(236 paginas)
No Manitowoc MULTIPLEX 11M Manual de instalación
(42 paginas)
(42 paginas)
© 2020, manymanuals.es. Todos los derechos reservados | 0.027 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comentarios a estos manuales